🐖 Chrysler Voyager Heater Not Working

fjb37. 562 posts · Joined 2003. #3 · Jan 19, 2013. Check the radiator drain plug. It may be leaking due to being loose or having a bad "O" ring seal. On my 94 GC it is on the driver's side of the radiator. When I drain the system I take off the lower hose. If you use a big enough pan you can catch most of the fluid. Just my $0.02. Chrysler Voyager 2002, HVAC Heater Core by Replace®. The heater core is located in a case under the dash, and is connected into the engine cooling system. Consists of tubes to carry the coolant and fins to transfer heat to the passenger cabin. The most common causes for AC blowing hot air in Chrysler Voyager are low or overcharged refrigerant, compressor malfunction, dirty condenser or evaporator coils, faulty blend door actuator, defective evaporator temperature sensor, bad AC pressure sensor, and bad fuse or relay. Less common causes are clogged expansion valve or orifice tube I have a 2010 T&C Limited with 4.0L and 3-zone ATC. The car has little to no heat. What I have done so far: 1) Topped off coolant, it's full. 2) Replaced thermostat, original was fine. 3) Replaced cabin air filter (was very dirty). No difference. 4) Pulled apart dash and checked all blend door servos; all working. 1,580. Asked by pat_paula Aug 18, 2011 at 10:20 PM about the 2002 Chrysler PT Cruiser. Question type: Maintenance & Repair. So my wife's 2002 cruiser runs hot and overheats when idle too long (drive thru, red light etc.). Checked debris between condensor and fan, fan works, coolant full, thermostat works, all relays good, changed egr valve and 118 posts · Joined 2006. #1 · Dec 17, 2010. The heat on my voyager is comming out not so hot. The heater hoses going into the firewall are kinda hot. I opened up the radiator cap as soon as I started it (cold start) and revved the engine a bit and the coolant went back into the radiator. So I know the water pump is ok. jbPurW.

chrysler voyager heater not working